- -

Improving membrane photobioreactor performance by reducing light path: operating conditions and key performance indicators

RiuNet: Repositorio Institucional de la Universidad Politécnica de Valencia

Compartir/Enviar a

Citas

Estadísticas

  • Estadisticas de Uso

Improving membrane photobioreactor performance by reducing light path: operating conditions and key performance indicators

Mostrar el registro sencillo del ítem

Ficheros en el ítem

Thumbnail
Nombre: Gonzalez-Camejo;A ...
Tamaño: 1.110Mb
Formato: PDF
Descripción: Versión del Autor.
Abrir
[Cerrado]
Nombre: WR_2020_Improving ...
Tamaño: 1.215Mb
Formato: PDF
Descripción: Versión editorial
Solicitar una copia al autor
dc.contributor.author Gonzalez-Camejo, Josue es_ES
dc.contributor.author Aparicio, S. es_ES
dc.contributor.author Jiménez Benítez, Antonio Luis es_ES
dc.contributor.author Paches Giner, Maria Aguas Vivas es_ES
dc.contributor.author Ruano, M. V. es_ES
dc.contributor.author Borrás, L. es_ES
dc.contributor.author Barat, Ramón es_ES
dc.contributor.author Seco, A. es_ES
dc.date.accessioned 2021-03-03T04:31:41Z
dc.date.available 2021-03-03T04:31:41Z
dc.date.issued 2020-04-01 es_ES
dc.identifier.issn 0043-1354 es_ES
dc.identifier.uri http://hdl.handle.net/10251/162858
dc.description ©IWA Publishing 2020. The definitive peer-reviewed and edited version of this article is published in Water Research, Volume 172, 1 April 2020, 115518 https://doi.org/10.1016/j.watres.2020.115518 and is available at www.iwapublishing.com. es_ES
dc.description.abstract [EN] Microalgae cultivation has been receiving increasing interest in wastewater remediation due to their ability to assimilate nutrients present in wastewater streams. In this respect, cultivating microalgae in membrane photobioreactors (MPBRs) allows decoupling the solid retention time (SRT) from the hydraulic retention time (HRT), which enables to increase the nutrient load to the photobioreactors (PBRs) while avoiding the wash out of the microalgae biomass. The reduction of the PBR light path from 25 to 10 cm increased the nitrogen and phosphorus recovery rates, microalgae biomass productivity and photosynthetic efficiency by 150, 103, 194 and 67%, respectively.The areal biomass productivity (aBP) also increased when the light path was reduced, reflecting the better use of light in the 10-cm MPBR plant. The capital and operating operational expenditures (CAPEX and OPEX) of the 10-cm MPBR plant were also reduced by 27 and 49%, respectively. Discharge limits were met when the 10-cm MPBR plant was operated at SRTs of 3-4.5 d and HRTs of 1.25-1.5 d. At these SRT/HRT ranges, the process could be operated without a high fouling propensity with gross permeate flux (J(20)) of 15 LMH and specific gas demand (SGD(p)) between 16 and 20 Nm(air)(3)center dot M-permeate(-3). which highlights the potential of membrane filtration in MPBRs. When the continuous operation of the MPBR plant was evaluated, an optical density of 680 nm (0D680) and soluble chemical oxygen demand (sCOD) were found to be good indicators of microalgae cell and algal organic matter (AOM) concentrations, while dissolved oxygen appeared to be directly related to MPBR performance. Nitrite and nitrate (NOx) concentration and the soluble chemical oxygen demand:volatile suspended solids ratio (sCOD:VSS) were used as indicators of nitrifying bacteria activity and the stress on the culture, respectively. These parameters were inversely related to nitrogen recovery rates and biomass productivity and could thus help to prevent possible culture deterioration. es_ES
dc.description.sponsorship This research work was supported by the Spanish Ministry of Economy and Competitiveness (MINECO, Projects CTM2014-54980-C2-1-R and CTM2014-54980-C2-2-R) jointly with the European Regional Development Fund (ERDF), both of which are gratefully acknowledged. It was also supported by the Spanish Ministry of Education, Culture and Sport via pre-doctoral FPU fellowship to authors J. Gonzalez-Camejo (FPU14/05082) and S. Aparicio (FPU/15/02595). es_ES
dc.language Inglés es_ES
dc.publisher Elsevier es_ES
dc.relation.ispartof Water Research es_ES
dc.rights Reconocimiento - No comercial - Sin obra derivada (by-nc-nd) es_ES
dc.subject Light path es_ES
dc.subject Membrane photobioreactor es_ES
dc.subject Microalgae es_ES
dc.subject Outdoor es_ES
dc.subject Performance indicator es_ES
dc.subject.classification TECNOLOGIA DEL MEDIO AMBIENTE es_ES
dc.subject.classification INGENIERIA HIDRAULICA es_ES
dc.title Improving membrane photobioreactor performance by reducing light path: operating conditions and key performance indicators es_ES
dc.type Artículo es_ES
dc.identifier.doi 10.1016/j.watres.2020.115518 es_ES
dc.relation.projectID info:eu-repo/grantAgreement/MINECO//CTM2014-54980-C2-1-R/ES/OBTENCION DE BIONUTRIENTES Y ENERGIA DEL AGUA RESIDUAL URBANA MEDIANTE CULTIVO DE MICROALGAS, TRATAMIENTOS ANAEROBIOS, CRISTALIZACION DE FOSFORO, ABSORCION DE NH3 Y COMPOSTAJE/ es_ES
dc.relation.projectID info:eu-repo/grantAgreement/MECD//FPU15%2F02595/ES/FPU15%2F02595/ es_ES
dc.relation.projectID info:eu-repo/grantAgreement/MINECO//CTM2014-54980-C2-2-R/ES/DESARROLLO DE UN SISTEMA DE CONTROL Y DE SOPORTE A LA DECISION PARA LA OBTENCION DE BIONUTRIENTES Y ENERGIA EN PROCESOS DE TRATAMIENTO DE AGUAS RESIDUALES URBANAS/ es_ES
dc.relation.projectID info:eu-repo/grantAgreement/MECD//FPU2014-05082/ES/FPU2014-05082/ es_ES
dc.rights.accessRights Abierto es_ES
dc.contributor.affiliation Universitat Politècnica de València. Departamento de Ingeniería Hidráulica y Medio Ambiente - Departament d'Enginyeria Hidràulica i Medi Ambient es_ES
dc.contributor.affiliation Universitat Politècnica de València. Instituto Universitario de Ingeniería del Agua y del Medio Ambiente - Institut Universitari d'Enginyeria de l'Aigua i Medi Ambient es_ES
dc.description.bibliographicCitation Gonzalez-Camejo, J.; Aparicio, S.; Jiménez Benítez, AL.; Paches Giner, MAV.; Ruano, MV.; Borrás, L.; Barat, R.... (2020). Improving membrane photobioreactor performance by reducing light path: operating conditions and key performance indicators. Water Research. 172:1-10. https://doi.org/10.1016/j.watres.2020.115518 es_ES
dc.description.accrualMethod S es_ES
dc.relation.publisherversion https://doi.org/10.1016/j.watres.2020.115518 es_ES
dc.description.upvformatpinicio 1 es_ES
dc.description.upvformatpfin 10 es_ES
dc.type.version info:eu-repo/semantics/publishedVersion es_ES
dc.description.volume 172 es_ES
dc.identifier.pmid 31991292 es_ES
dc.relation.pasarela S\401252 es_ES
dc.contributor.funder Ministerio de Educación es_ES
dc.contributor.funder Ministerio de Economía y Empresa es_ES
dc.contributor.funder European Regional Development Fund es_ES
dc.contributor.funder Ministerio de Economía y Competitividad es_ES
dc.contributor.funder Ministerio de Educación, Cultura y Deporte es_ES
dc.description.references Arbib, Z., de Godos, I., Ruiz, J., & Perales, J. A. (2017). Optimization of pilot high rate algal ponds for simultaneous nutrient removal and lipids production. Science of The Total Environment, 589, 66-72. doi:10.1016/j.scitotenv.2017.02.206 es_ES
dc.description.references Barceló-Villalobos, M., Fernández-del Olmo, P., Guzmán, J. L., Fernández-Sevilla, J. M., & Acién Fernández, F. G. (2019). Evaluation of photosynthetic light integration by microalgae in a pilot-scale raceway reactor. Bioresource Technology, 280, 404-411. doi:10.1016/j.biortech.2019.02.032 es_ES
dc.description.references Day, J. G., Gong, Y., & Hu, Q. (2017). Microzooplanktonic grazers – A potentially devastating threat to the commercial success of microalgal mass culture. Algal Research, 27, 356-365. doi:10.1016/j.algal.2017.08.024 es_ES
dc.description.references Fernández, I., Acién, F. G., Guzmán, J. L., Berenguel, M., & Mendoza, J. L. (2016). Dynamic model of an industrial raceway reactor for microalgae production. Algal Research, 17, 67-78. doi:10.1016/j.algal.2016.04.021 es_ES
dc.description.references Fernández-Sevilla, J. M., Brindley, C., Jiménez-Ruíz, N., & Acién, F. G. (2018). A simple equation to quantify the effect of frequency of light/dark cycles on the photosynthetic response of microalgae under intermittent light. Algal Research, 35, 479-487. doi:10.1016/j.algal.2018.09.026 es_ES
dc.description.references Ferreira, G. F., Ríos Pinto, L. F., Maciel Filho, R., & Fregolente, L. V. (2019). A review on lipid production from microalgae: Association between cultivation using waste streams and fatty acid profiles. Renewable and Sustainable Energy Reviews, 109, 448-466. doi:10.1016/j.rser.2019.04.052 es_ES
dc.description.references Ferrer, J., Pretel, R., Durán, F., Giménez, J. B., Robles, A., Ruano, M. V., … Seco, A. (2015). Design methodology for submerged anaerobic membrane bioreactors (AnMBR): A case study. Separation and Purification Technology, 141, 378-386. doi:10.1016/j.seppur.2014.12.018 es_ES
dc.description.references Galès, A., Bonnafous, A., Carré, C., Jauzein, V., Lanouguère, E., Le Floc’h, E., … Fouilland, E. (2019). Importance of ecological interactions during wastewater treatment using High Rate Algal Ponds under different temperate climates. Algal Research, 40, 101508. doi:10.1016/j.algal.2019.101508 es_ES
dc.description.references Gao, F., Cui, W., Xu, J.-P., Li, C., Jin, W.-H., & Yang, H.-L. (2019). Lipid accumulation properties of Chlorella vulgaris and Scenedesmus obliquus in membrane photobioreactor (MPBR) fed with secondary effluent from municipal wastewater treatment plant. Renewable Energy, 136, 671-676. doi:10.1016/j.renene.2019.01.038 es_ES
dc.description.references Garrido-Cardenas, J. A., Manzano-Agugliaro, F., Acien-Fernandez, F. G., & Molina-Grima, E. (2018). Microalgae research worldwide. Algal Research, 35, 50-60. doi:10.1016/j.algal.2018.08.005 es_ES
dc.description.references González-Camejo, J., Aparicio, S., Ruano, M. V., Borrás, L., Barat, R., & Ferrer, J. (2019). Effect of ambient temperature variations on an indigenous microalgae-nitrifying bacteria culture dominated by Chlorella. Bioresource Technology, 290, 121788. doi:10.1016/j.biortech.2019.121788 es_ES
dc.description.references González-Camejo, J., Jiménez-Benítez, A., Ruano, M. V., Robles, A., Barat, R., & Ferrer, J. (2019). Preliminary data set to assess the performance of an outdoor membrane photobioreactor. Data in Brief, 27, 104599. doi:10.1016/j.dib.2019.104599 es_ES
dc.description.references González-Camejo, J., Barat, R., Aguado, D., & Ferrer, J. (2020). Continuous 3-year outdoor operation of a flat-panel membrane photobioreactor to treat effluent from an anaerobic membrane bioreactor. Water Research, 169, 115238. doi:10.1016/j.watres.2019.115238 es_ES
dc.description.references Henderson, R. K., Baker, A., Parsons, S. A., & Jefferson, B. (2008). Characterisation of algogenic organic matter extracted from cyanobacteria, green algae and diatoms. Water Research, 42(13), 3435-3445. doi:10.1016/j.watres.2007.10.032 es_ES
dc.description.references Huang, J., Hankamer, B., & Yarnold, J. (2019). Design scenarios of outdoor arrayed cylindrical photobioreactors for microalgae cultivation considering solar radiation and temperature. Algal Research, 41, 101515. doi:10.1016/j.algal.2019.101515 es_ES
dc.description.references Iasimone, F., De Felice, V., Panico, A., & Pirozzi, F. (2017). Experimental study for the reduction of CO 2 emissions in wastewater treatment plant using microalgal cultivation. Journal of CO2 Utilization, 22, 1-8. doi:10.1016/j.jcou.2017.09.004 es_ES
dc.description.references Jebali, A., Acién, F. G., Rodriguez Barradas, E., Olguín, E. J., Sayadi, S., & Molina Grima, E. (2018). Pilot-scale outdoor production of Scenedesmus sp. in raceways using flue gases and centrate from anaerobic digestion as the sole culture medium. Bioresource Technology, 262, 1-8. doi:10.1016/j.biortech.2018.04.057 es_ES
dc.description.references Judd, S., van den Broeke, L. J. P., Shurair, M., Kuti, Y., & Znad, H. (2015). Algal remediation of CO2 and nutrient discharges: A review. Water Research, 87, 356-366. doi:10.1016/j.watres.2015.08.021 es_ES
dc.description.references Lee, J.-C., Baek, K., & Kim, H.-W. (2018). Semi-continuous operation and fouling characteristics of submerged membrane photobioreactor (SMPBR) for tertiary treatment of livestock wastewater. Journal of Cleaner Production, 180, 244-251. doi:10.1016/j.jclepro.2018.01.159 es_ES
dc.description.references Bin Liu, Qu, F., Liang, H., Gan, Z., Yu, H., Li, G., & Van der Bruggen, B. (2017). Algae-laden water treatment using ultrafiltration: Individual and combined fouling effects of cells, debris, extracellular and intracellular organic matter. Journal of Membrane Science, 528, 178-186. doi:10.1016/j.memsci.2017.01.032 es_ES
dc.description.references Luo, Y., Le-Clech, P., & Henderson, R. K. (2018). Assessment of membrane photobioreactor (MPBR) performance parameters and operating conditions. Water Research, 138, 169-180. doi:10.1016/j.watres.2018.03.050 es_ES
dc.description.references Luo, Y., Henderson, R. K., & Le-Clech, P. (2019). Characterisation of organic matter in membrane photobioreactors (MPBRs) and its impact on membrane performance. Algal Research, 44, 101682. doi:10.1016/j.algal.2019.101682 es_ES
dc.description.references Norsker, N.-H., Barbosa, M. J., Vermuë, M. H., & Wijffels, R. H. (2011). Microalgal production — A close look at the economics. Biotechnology Advances, 29(1), 24-27. doi:10.1016/j.biotechadv.2010.08.005 es_ES
dc.description.references Nwoba, E. G., Parlevliet, D. A., Laird, D. W., Alameh, K., & Moheimani, N. R. (2019). Light management technologies for increasing algal photobioreactor efficiency. Algal Research, 39, 101433. doi:10.1016/j.algal.2019.101433 es_ES
dc.description.references Razzak, S. A., Ali, S. A. M., Hossain, M. M., & deLasa, H. (2017). Biological CO2 fixation with production of microalgae in wastewater – A review. Renewable and Sustainable Energy Reviews, 76, 379-390. doi:10.1016/j.rser.2017.02.038 es_ES
dc.description.references Romero Villegas, G. I., Fiamengo, M., Acién Fernández, F. G., & Molina Grima, E. (2017). Outdoor production of microalgae biomass at pilot-scale in seawater using centrate as the nutrient source. Algal Research, 25, 538-548. doi:10.1016/j.algal.2017.06.016 es_ES
dc.description.references Rossi, S., Bellucci, M., Marazzi, F., Mezzanotte, V., & Ficara, E. (2018). Activity assessment of microalgal-bacterial consortia based on respirometric tests. Water Science and Technology, 78(1), 207-215. doi:10.2166/wst.2018.078 es_ES
dc.description.references Ruiz, J., Arbib, Z., Álvarez-Díaz, P. D., Garrido-Pérez, C., Barragán, J., & Perales, J. A. (2014). Influence of light presence and biomass concentration on nutrient kinetic removal from urban wastewater by Scenedesmus obliquus. Journal of Biotechnology, 178, 32-37. doi:10.1016/j.jbiotec.2014.03.001 es_ES
dc.description.references Seco, A., Aparicio, S., González-Camejo, J., Jiménez-Benítez, A., Mateo, O., Mora, J. F., … Ferrer, J. (2018). Resource recovery from sulphate-rich sewage through an innovative anaerobic-based water resource recovery facility (WRRF). Water Science and Technology, 78(9), 1925-1936. doi:10.2166/wst.2018.492 es_ES
dc.description.references Sepúlveda, C., Acién, F. G., Gómez, C., Jiménez-Ruíz, N., Riquelme, C., & Molina-Grima, E. (2015). Utilization of centrate for the production of the marine microalgae Nannochloropsis gaditana. Algal Research, 9, 107-116. doi:10.1016/j.algal.2015.03.004 es_ES
dc.description.references Slegers, P. M., Wijffels, R. H., van Straten, G., & van Boxtel, A. J. B. (2011). Design scenarios for flat panel photobioreactors. Applied Energy, 88(10), 3342-3353. doi:10.1016/j.apenergy.2010.12.037 es_ES
dc.description.references Solovchenko, A., Khozin-Goldberg, I., Selyakh, I., Semenova, L., Ismagulova, T., Lukyanov, A., … Gorelova, O. (2019). Phosphorus starvation and luxury uptake in green microalgae revisited. Algal Research, 43, 101651. doi:10.1016/j.algal.2019.101651 es_ES
dc.description.references Thomas, P. K., Dunn, G. P., Good, A. R., Callahan, M. P., Coats, E. R., Newby, D. T., & Feris, K. P. (2019). A natural algal polyculture outperforms an assembled polyculture in wastewater-based open pond biofuel production. Algal Research, 40, 101488. doi:10.1016/j.algal.2019.101488 es_ES
dc.description.references Viruela, A., Robles, Á., Durán, F., Ruano, M. V., Barat, R., Ferrer, J., & Seco, A. (2018). Performance of an outdoor membrane photobioreactor for resource recovery from anaerobically treated sewage. Journal of Cleaner Production, 178, 665-674. doi:10.1016/j.jclepro.2017.12.223 es_ES
dc.description.references Xu, X., Gu, X., Wang, Z., Shatner, W., & Wang, Z. (2019). Progress, challenges and solutions of research on photosynthetic carbon sequestration efficiency of microalgae. Renewable and Sustainable Energy Reviews, 110, 65-82. doi:10.1016/j.rser.2019.04.050 es_ES
dc.subject.ods 06.- Garantizar la disponibilidad y la gestión sostenible del agua y el saneamiento para todos es_ES


Este ítem aparece en la(s) siguiente(s) colección(ones)

Mostrar el registro sencillo del ítem