Age influence on effectiveness of a novel 3-phytase in barley-wheat based diets for pigs from 12 to 108 kg under commercial conditions

Abstract

[EN] The main objective of this study was to evaluate the influence of pig's age on the effectiveness of a new microbial 3-phytase, produced by Komagataella phaffii, under commercial conditions in barley-wheat based diets. Two experiments were conducted in weaned, growing and finishing pigs; firstly, to determine phytase efficacy on dry matter, organic matter, energy, protein and mineral (phosphorus, P and calcium, Ca) digestibility (n = 48; Experiment 1), and secondly, to evaluate the effect of phytase on growth performance and bone mineralization (n = 312; Experiment 2). In each experiment, three barley-wheat based diets were formulated following the recommendations for each animal age, of which two versions were manufactured, including 0 and 1000 phytase units (FTU)/kg of feed of the new 3-phytase to be tested. Results showed the new phytase had the potential to increase the digestibility of Ca and P (on av. + 0.05 and +0.06, respectively; P < 0.01), especially P digestibility in growing pigs (+0.10; P < 0.001), consequently decreasing P and Ca excretion. Digestible energy (DE) of the diet increased with the addition of phytase in weaned pigs (+0.69 MJ/kg of dry matter (DM); P < 0.001). Dietary inclusion of new 3-phytase enhanced average daily gain from 46 to 94 days of age (+0.07 kg/d; P < 0.05) and decreased feed conversion ratio from 46 to 154 days of age (on av. -0.13; P < 0.05), although no significant effect was observed from 154 to 185 days of age. Addition of the new 3-phytase also promoted bone mineralization, increasing the weight of the bones (+3.99 and +3.64 g of tibia at 95 days and metacarpus at 100 days of age, respectively; P < 0.05) and the ash, Ca and P content in these bones (e.g. + 0.46 and +0.33 g of P in tibia at 95 days and metacarpus at 100 days of age, respectively; P < 0.001). In conclusion, pig age affected the efficacy of a new 3-phytase on P and Ca digestibility both in weaned and growing diets and DE content of the weaned diets, which also resulted in improvements in growth, feed conversion and bone development until 154 days of age. These effects seem to be reduced during the finishing period, although the advantages of the new 3-phytase on bone mineralization were maintained until 185 days of age.