Influence of ripening stage and de-astringency treatment on the production of dehydrated persimmon snacks

Abstract

[EN] BACKGROUND Seasonal persimmon (Diospyros kakiL.) crops have steadily increased in Spain; this has been linked to a significant increase in the postharvest production waste. Therefore, development of valorized products is of great interest. In this study, a hot air-drying technique was used to obtain persimmon snacks. Slices from astringent and non-astringent persimmons (submitted to de-astringency treatment) at three different ripening stages were dried at 40 and 60 degrees C to reach 15 +/- 3% water content. RESULTS After the drying treatment, dehydrated samples were harder, turned into a more orange hue angle, and had a reduced soluble tannin content. Dehydrated samples obtained from the astringent fruit at the most advanced ripening stage had similar soluble tannin content as the samples obtained from non-astringent fruit, especially at 60 degrees C. Besides, a high correlation was observed between the level of astringency perceived by consumers and the decrease of soluble tannin content. Although, in the first ripening stage, consumers preferred the snacks obtained from non-astringent fruits; in the last ripening stage, snacks produced from astringent fruits were equally accepted than the non-astringent ones. CONCLUSION Therefore, well-accepted persimmon snacks are obtained from both astringent and non-astringent fruits when advanced ripening stages of persimmon are used.